Selection, use and the influence of starter cultures in the nutrition and processing improvement of ogi

Article Information

Olakunle David Teniola1*, Wilhelm H Holzapfel2, Sunday Ayodele Odunfa3

1Olusegun Agagu University of Science and Technology (OAUSTECH), PMB 353 Okitipupa, Nigeria

2School of Life Sciences, Handong Global University, Pohang, Gyeongbuk 791-798, Republic of Korea      

3Botany and Microbiology Department, University of Ibadan, Ibadan, Nigeria

*Corresponding Author: Olakunle David Teniola, Olusegun Agagu University of Science and Technology (OAUSTECH), PMB 353 Okitipupa, Nigeria

Received: 17 May 2023; Accepted: 09 June 2023; Published: 19 July 2023

Citation: Olakunle David Teniola, Wilhelm H Holzapfel, Sunday Ayodele Odunfa. Selection, use and the influence of starter cultures in the nutrition and processing improvement of ogi. Journal of Food Science and Nutrition Research. 6 (2023): 61-70.

View / Download Pdf Share at Facebook


The selection criteria of starter cultures (SCS) used for ogi production were reported. These SCS were used with the aim of improving processing technique, and lysine and methionine levels of ogi, a lactic acid fermented weaning food limiting in these two amino acids. Lactobacillus brevis XO43 and Saccharomyces cerevisiae OY4 were used as SCS in a pilot plant study. Fermentation with SCS showed a constant final pH level of 3.35 in modified substrates after fermentation unlike spontaneously fermented; and significantly higher acidity (%TTA) indicative of faster fermentation. The addition of sugar (2% w/w) and soybean flour (1% w/w) also increased the acid levels during fermentation. Fermentation of dehulled maize (DM) grains fortified with glucose (2%w/w) alone by SCS shows the best quality in all the parameters considered except the available niacin yield. The lysine is 24% higher than oven-dried ogi flour from the traditionally fermented (TF) and 11% higher than unprocessed whole maize grains (WMG). The methionine is 92% and 77% higher than the TF ogi and WMG, respectively. The total amino acids level of the sample was 32% more than the TF ogi flour and 55% more than WMG. Although, the soluble protein level was 23% lesser than the unfermented WMG, it was 12% more than the DM substrate and ogi from TF. Fermentation of corn into ogi led to losses in the initial quantity of niacin. SCS significantly improve the nutrients such as lysine, methionine, total amino acids, soluble protein and niacin more than spontaneous fermentation. Dehulling of grains, dewatering and oven drying significantly reduce nutrients. Ogi fermentation process with the use of SCS and DM guarantee organoleptic qualities, improve ogi production by eliminating wet-sieving, limiting water usage, and creating better nutritional products.


Ogi, Starter culture, Lysine, Methionine, Niacin, Lactic acid fermentation, Nutritional improvement, Process improvement

Ogi articles; Starter culture articles; Lysine articles; Methionine articles; Niacin articles; Lactic acid fermentation articles; Nutritional improvement articles; Process improvement articles

Ogi articles Ogi Research articles Ogi review articles Ogi PubMed articles Ogi PubMed Central articles Ogi 2023 articles Ogi 2024 articles Ogi Scopus articles Ogi impact factor journals Ogi Scopus journals Ogi PubMed journals Ogi medical journals Ogi free journals Ogi best journals Ogi top journals Ogi free medical journals Ogi famous journals Ogi Google Scholar indexed journals Starter culture articles Starter culture Research articles Starter culture review articles Starter culture PubMed articles Starter culture PubMed Central articles Starter culture 2023 articles Starter culture 2024 articles Starter culture Scopus articles Starter culture impact factor journals Starter culture Scopus journals Starter culture PubMed journals Starter culture medical journals Starter culture free journals Starter culture best journals Starter culture top journals Starter culture free medical journals Starter culture famous journals Starter culture Google Scholar indexed journals Lysine articles Lysine Research articles Lysine review articles Lysine PubMed articles Lysine PubMed Central articles Lysine 2023 articles Lysine 2024 articles Lysine Scopus articles Lysine impact factor journals Lysine Scopus journals Lysine PubMed journals Lysine medical journals Lysine free journals Lysine best journals Lysine top journals Lysine free medical journals Lysine famous journals Lysine Google Scholar indexed journals Methionine articles Methionine Research articles Methionine review articles Methionine PubMed articles Methionine PubMed Central articles Methionine 2023 articles Methionine 2024 articles Methionine Scopus articles Methionine impact factor journals Methionine Scopus journals Methionine PubMed journals Methionine medical journals Methionine free journals Methionine best journals Methionine top journals Methionine free medical journals Methionine famous journals Methionine Google Scholar indexed journals Niacin articles Niacin Research articles Niacin review articles Niacin PubMed articles Niacin PubMed Central articles Niacin 2023 articles Niacin 2024 articles Niacin Scopus articles Niacin impact factor journals Niacin Scopus journals Niacin PubMed journals Niacin medical journals Niacin free journals Niacin best journals Niacin top journals Niacin free medical journals Niacin famous journals Niacin Google Scholar indexed journals Lactic acid fermentation articles Lactic acid fermentation Research articles Lactic acid fermentation review articles Lactic acid fermentation PubMed articles Lactic acid fermentation PubMed Central articles Lactic acid fermentation 2023 articles Lactic acid fermentation 2024 articles Lactic acid fermentation Scopus articles Lactic acid fermentation impact factor journals Lactic acid fermentation Scopus journals Lactic acid fermentation PubMed journals Lactic acid fermentation medical journals Lactic acid fermentation free journals Lactic acid fermentation best journals Lactic acid fermentation top journals Lactic acid fermentation free medical journals Lactic acid fermentation famous journals Lactic acid fermentation Google Scholar indexed journals Nutritional improvement articles Nutritional improvement Research articles Nutritional improvement review articles Nutritional improvement PubMed articles Nutritional improvement PubMed Central articles Nutritional improvement 2023 articles Nutritional improvement 2024 articles Nutritional improvement Scopus articles Nutritional improvement impact factor journals Nutritional improvement Scopus journals Nutritional improvement PubMed journals Nutritional improvement medical journals Nutritional improvement free journals Nutritional improvement best journals Nutritional improvement top journals Nutritional improvement free medical journals Nutritional improvement famous journals Nutritional improvement Google Scholar indexed journals Process improvement articles Process improvement Research articles Process improvement review articles Process improvement PubMed articles Process improvement PubMed Central articles Process improvement 2023 articles Process improvement 2024 articles Process improvement Scopus articles Process improvement impact factor journals Process improvement Scopus journals Process improvement PubMed journals Process improvement medical journals Process improvement free journals Process improvement best journals Process improvement top journals Process improvement free medical journals Process improvement famous journals Process improvement Google Scholar indexed journals

Article Details


Ogi is a common West African lactic acid fermented staple food from maize, sorghum, or millet [1,2]. The popularity and general acceptance of ogi has encouraged various works on microbiology [1,2], economic impact [3], nutrition [4-7], mycotoxin safety [8-10], the production techniques [11-13] and spoilage [14-16]. Despite all the attention indicated above, most of the efforts have been based on product analyses or evaluations. Only a few works have been focused on the application of starter cultures to solve specific problems related to ogi processing and product improvement [17,18]. The Federal Institute of Industrial Research, Oshodi (FIIRO), Lagos, Nigeria, developed a pilot process plant for ogi production based on the traditional procedure that requires spontaneous fermentation [11]. Although, this has encouraged better product presentation, packaging, increased shelf life and increased output, a more efficient fermentation requires definite SCS. Products resulting from the present spontaneous fermentation process are not likely to be reproducible worldwide due to varying microflora and environmental conditions. The spontaneous fermentation been used without definite microorganisms has discouraged the potential use of modern microbial biotechnology techniques to improve the product quality through the use of defined microbial SCS [19]. The application of SCS or its byproducts during processing can reduce production time, further increase shelf-life and nutritional attributes [16-18]. The Lactobacillus brevis and other lactic acid bacteria (LAB) contribute to the sour and acidic taste, while Saccharomyces cerevisiae contributes to the aroma of ogi and improves the LAB’s stability [20,21]. Previous attempts to improve the nutritional qualities of ogi in the past have been based mostly on product fortification with legumes such as groundnut, pinto, soybean, pigeon pea and cowpea to boost the deficient amino acid levels, such as lysine levels which are generally limiting in cereals especially those used for ogi production raw materials [22-25]; while this has been achieved, a different product emerged that is different from ogi in taste, aroma, and general acceptability hence such names as soy-ogi, walnut-ogi, e.t.c. [6,11,26]. Wang et al. [27] noted that an induced increase in kernels' niacin concentration is necessary for improving maize kernels’ nutrition. Methionine is also limiting in most legumes used to fortify ogi for better nutritive products [28-30]. 

The traditional practice of daily replacement of sour water on ogi to prolong the shelf life is cumbersome and may reduce the nutritional value through the loss of water-soluble nutrients. The use of starters in controlled ogi fermentation has the advantage of utilizing the vast potentials of the lactic acid bacteria and other useful micro-organisms present in the natural fermentation to improve ogi shelf life and solve various health and nutritional problems. Olukoya et al. [17] developed an improved ogi named `DogiK´ with potential use in the prevention and treatment of diarrhoea by using Lactobacillus SCS with antagonistic activity against diarrhoeagenic bacteria (and also possessing amylolytic activity). The product is active against pathogens in cooked and uncooked form and at neutral pH [31,32]. LAB and yeast from ogi and other related sources have been identified with important features that enhance quality ogi production such as the production of antimicrobial substances against major pathogens and spoilage microorganisms [33-35], various enzymes that are capable of degrading anti-nutritional factors like phytate, protease inhibitors and oligosaccharides [36,37], as well as production of amino acids such as lysine and methionine [5,38]. None production of biogenic amines (BAs) like Histamine and cadaverine that can be formed by converting histidine and lysine via histidine decarboxylase (HDC) and via lysine decarboxylase (LDC), respectively [39] is also a desirable quality. This work is aimed at selecting and demonstrating the ability of the selected lysine- and methionine-producing SCS to improve the lysine and methionine levels of ogi in a pilot plant study. Earlier attempts were carried out at the laboratory level. The implication of certain steps employed during processing and their effects on the final product will also be investigated.

Materials and Methods

2.1 Screening of starter cultures (SCS)

Isolates of LAB and yeast cultures obtained during ogi processing were screened and further details established to obtain ogi potential SCS. SCS were revealed by initially checking for important technical features of the isolates including lysine and methionine production yields. Most importantly, the ability to produce an acceptable ogi aroma was carried out in a covered boiling tube study.

2.1.1 Technical features of LAB and yeast isolates

Isolates of LAB were tested for conformity with the following important technical features such as: pH 4.0 reduction ability [40,41], acid production from oligosaccharides raffinose and stachyose [42], bacteriocin producing microorganisms screening based on significant inhibitions against test microorganisms such as Listeria monocytogenes, Listeria innocua ATCC33090, Staphylococcus aureus ATCC 43300, Enterococcus faecalis, Escherichia coli ATCC25922, Klebsiella pneumoniae and Proteus vulgaris by using agar diffusion test. Cell free crude supernatant (24h) of each isolate was obtained by centrifugation at 3,000xg for 20 minutes. The supernatant was adjusted to pH 6.5 with 1M NaOH and subsequently filter sterilized through a 0.2µm membrane filter (Whatman, Germany). Inhibitory activity was determined using agar well diffusion assay [43,44], and phytase production was according to growth on minimal salt medium containing (% w/v): Dextrose, 0.5; peptone, 1.0; yeast extract, 0.5; MgSO4, 0.1; CaCl2, 0.1, and sodium phytate, 0.1 (pH 7.0). The differential medium use the disappearance of precipitated calcium and sodium phytate in the medium after incubation period as an indication of phytase enzyme presence [45]. Biogenic amine (BAs) none production [39,46,47] among the isolates tested from different sources were by growing in de Man, Rogosa and Sharpe (MRS) broth (Oxoid CM0359) at 37°C for 24-48 h. Production of BAs from each isolate was determined using the Moller’s decarboxylase base broth (MDB) (pH 5.3) containing 0.05% precursor such as L-histidine, L-tyrosine, L-lysine and L-ornithine [48]. The screened isolates were inoculated to the MDB with and without precursor (as control) at 37°C for 4 days and 7 days respectively. The colour of Moller’s decarboxylase base medium changed from yellow to purple after incubation indicates positive for BAs production, whereas if the broth remained yellow, it will indicate negative for BAs production.
Both LAB and yeasts isolates were effectively screened for lysine and methionine overproduction as exhibited by the two organisms’ growth in minimal growth plates with high concentrations of thialysine and ethionine, respectively [38,49,50].

2.1.2 Microbial screening of acceptable  Ogi SCS

Promising isolates were further tested and selected for use as potential ogi SCS.  Fresh cultures (24h) of LAB and yeast previously screened for important features of fermentation (2.1.1 above) were used. Pure cultures of the test micro-organisms were grown in screw cap tubes containing 10 ml sterile de Man, Rogosa and Sharpe (MRS) broth (Oxoid CM0359) and Sabouraud Dextrose Liquid medium broth (Oxoid CM0147) for LAB and yeast growth, respectively. The 24h-old culture broths were each washed twice in sterile distilled water by centrifugation at 3000 g value for 10 min using Sorvall RC5C refrigerated centrifuge. The pellets obtained from the culture broth were suspended again in sterile distilled water to form inoculum cell suspension containing 108-1010 c.f.u. /ml viable counts.

The test microorganisms were inoculated into sterile mixture of maize flours (5g) and distilled water. This was prepared by sterilization of the dried flour at 121 0C in an autoclave for 15 minutes. The cooled sterile dried flour was aseptically hydrated with 20 ml of sterile distilled water at ambient temperature. The well shaken maize flour suspensions were each inoculated with 3 ml of the prepared inoculum suspension (as described above) singly and in combinations. The inoculated maize flour solutions above were incubated at 30 0C temperature for 24h. After incubation, changes in the pH, TTA, dissolved hydrogen sulphide (H2S) and odour (acceptability) were noted. The odour changes were obtained by the mean score of a 5-man panel. Ogi samples inoculated with sterile distilled water were used as control while freshly produced hydrated ogi from the local market served as reference.

2.2 Selected starter cultures

Saccharomyces cerevisiae OY4 and a hetero-fermentative Lactobacillus brevis XO43 were identified as ogi starter cultures with lysine and methionine overproducing capabilities [38]. They were used for the later pilot plant fermentation. 

2.3 Inoculum production for fermentation

Twenty-four hours cultures of S. cerevisiae OY4 and L. brevis XO43 on agar slants were prepared according to 2.1.2.

2.4 Fermentation experiment

The raw materials used for the laboratory studies include maize and soybean flour which were purchased at Idi-Oro market, Mushin, Lagos. Fifteen kilograms (15kg) of DM grains were used for each fermentation. The substrates were made up of substrates: (A) DM grains alone; (B) DM grains and glucose (2%w/w); (C) DM grains, glucose (2%w/w), and soybean flour (1%w/w). These were each mixed with 32 litres of tap water and inoculated with 1.6 litres of well mixed equal proportions of L. brevis XO43 and S. cerevisiae OY4 prepared inoculum above [107-108 c. f. u. /ml confirmed by microbial plate count using MRS agar (Oxoid CM 361) and Sabouraud Dextrose Agar (SDA) (Oxoid CM 41)]. A non-inoculated spontaneously fermented set from the substrates described above were used as the control; while WMG spontaneously steeped and fermented as done traditionally was used as a reference control [11]. After 24 h of steeping, the fermented grains were wet-milled using a double grinding mill (Model: Asiko A11, Addis Engineering, Nigeria). The wet-milled mash was further fermented for 48h. The traditionally prepared reference control from WMG was wet-sieved before further fermentation. After fermentation, the pH and percentage total titratable acidity of the fermented mash samples were measured [18]. Lactobacillus brevis XO43 and Saccharomyces cerevisiae OY4 used as SCS were isolated and confirmed with the stock cultures using various morphological and biochemical tests. The representative samples of each of the fermentation sets were freeze-dried at - 40oC temperature using a Labconco freeze-dryer (Lyph-Lock 6, Labconco Co., Kansas City, USA). The water of the fermented mash samples were removed and the water extract was kept at -20oC temperature for subsequent analyses. The wet-cakes were oven-dried using a Mitchell tray oven-drier (L. A. Mitchell Ltd. Drying Engineers, Ref. No. 008404/63/Exp, Manchester, England) at 55oC to obtain ogi flakes. These flakes were milled into powder in a disk mill (Apex-Mill, Apex Construction Ltd., England) and packaged in polyethylene (plastic) bags. The final samples were stored at -20oC temperature prior to analyses. The experiments were set up in duplicates.

2.5 Chemical analyses

The pH and total titratable acidity (TTA) were determined directly from the fermentation mash prior to drying according to the method of Okoroafor et al [18]. Total amino acids assessment was according to Rosen [51] while the method of Waterborg, and Matthew [52] was used for the total soluble protein determination.

2.6 Determination of lysine, methionine and niacin

Test materials were prepared according to AOAC methods. The samples were analysed for the availability of lysine, methionine, and niacin by microbiological assays [49,53].

2.7 Organoleptic (sensory) evaluation test

A 7-man trained panel who were familiar with ogi were asked to assess the qualities of the 48 h fermented samples considering the colour or appearance, aroma, taste, sourness after taste, mouth feel consistency and overall acceptability as reported. This was then analysed statistically as described by analysis of variance (ANOVA) using the statistical software SPSS 20.0, and means were compared by the Duncan`s Multiple Range Test (0.05 level) as described by Cass [54].

2.8 Data availability statements

The data that support the findings of this study are available from “Federal Institute of Industrial Research, Oshodi (FIIRO), Lagos, Nigeria”; where the corresponding author works during the duration of the practical work, but restrictions apply to the availability of these raw data, which were used under license for the current study, and so are not publicly available. Data are however available from the corresponding author upon reasonable request and with permission of ”The Federal Institute of Industrial Research, Oshodi (FIIRO), Lagos, Nigeria”.


Important characteristics of the screened LAB isolates vary depending on LAB groups as shown in table 1. It was observed that Pediococcus has the highest percentage population (96.92%,) to be able to reduce the pH of MRS broth below 4.0. This is followed by homo-fermentative Lactobacillus at 91.4%, then Enterococcus (20%), hetero-fermentative Lactobacillus (8%) and Lactococcus (4.17%). The highest frequency of phytase degraders was found amongst homo-fermentative Lactobacillus (57.14%). These were followed by Pediococcus (36.92), Lactococcus (37.5%), hetero-fermentative Lactobacillus (16%) and Enterococcus (5%). Out of the different groups of 170 isolates, only Lactococcus was able to produce bacteriocin (12.5%). The degradation of oligosaccharides such as stachyose and raffinose by different categories of lactic acid bacteria was analyses. Stachyose degradation was most profound in homo-fermentative Lactobacillus (45.71%) followed by Enterococcus (45%), Pediococcus (44.62%), Lactococcus (25%) and hetero-fermentative Lactobacillus (16%). Lastly raffinose sugar degradation is most frequent in homo-fermentative Lactobacillus (94.29 %), followed by Pediococcus (90.77%). Enterococcus showed 65 % degraders of raffinose, followed hetero-fermentative Lactobacillus (48%) and Lactococcus (33.33%). Only one culture of the Leuconostoc was isolated, which was however negative to all the features tested (table 1). It was also established from the study that none of the isolates screened produced biogenic amines.

Table 1: Characteristics of lactic acid bacteria screened as ogi starter cultures

Table icon

Natural lysine and methionine production study of Lactobacillus spp and yeasts in batch fermentation of ogi showed that 43% of the Lactobacillus and 83% of the yeast isolates tested were capable of lysine overproduction while 25% of the Lactobacillus and 88% of the yeast isolates overproduced methionine. The profile features of the selected SCS isolates of Lactobacillus brevis XO43 and Saccharomyces cerevisiae are shown in table 2. The changes in the pH and the percentage total titratable acidity (%TTA) of the fermented mash after 3 days of fermentation are presented in table 3. Fermentation substrates pre-inoculated with SCS showed a similar pH level of 3.35 after fermentation in contrast with the variable pH readings for the spontaneously fermented. The pH 3.35 level was slightly lower but close to the pH 3.40 observed in the traditional fermented reference ogi sample from WMG. Fermentation with SCS gave products with higher acidity (%TTA) than the spontaneous fermentations (table 3). Addition of sugar and soybean flours also increased the acid levels during fermentation. Nutrients such as lysine, methionine, total amino acids, soluble protein and niacin reduced when WMG were dehulled (tables 4 and 5). Freeze-dried ogi analyses indicated that the use of SCS increased the levels of the available lysine and methionine. The total amino acids and soluble protein also increased more after fermentation when compared with spontaneously fermented freeze-dried controls and the unfermented DM grains used as the substrates (tables 5). Fermentation of DM grains fortified with glucose (2%w/w) alone by SCS shows the best quality in all the parameters considered except the available niacin (tables 4 and 5). It is 24% higher than oven-dried ogi flour from the traditional fermentation and 11% higher than unprocessed WMG. The methionine level of the sample from this fermentation fortified with added glucose and fermented with SCS was 92% and 77% higher than the traditionally prepared ogi sample and unfermented whole maize grains, respectively. The total amino acids level of the sample was 32% more than the traditionally fermented ogi flour and 55% more than WMG. Although, the soluble proteins level was 23% lesser than the unfermented WMG, it was still 12% more than the DM substrate and ogi from traditional process. The reduced lysine and methionine levels when maize substrate added with glucose (substrate B) was further fortified by adding 1% (w/w) soybean flour as additional nitrogen source (substrate C) was against our expectation based on earlier physiological studies on the starter cultures (tables 4,5). The results show that fermentation of corn into ogi led to losses in the initial quantity of niacin that is available in the raw materials. All the fermentation products show lesser quantities of niacin than the unprocessed WMG. There were higher levels of available lysine, methionine, total amino acids, soluble proteins, and niacin in the freeze-dried than in the oven-dried samples (tables 4 and 5). Organoleptic or sensory study of the products of the pilot-plant produced ogi as shown in table 6 confirmed that good quality ogi product were obtained from dehulled maize grain substrate and SCS, which are improved processing techniques confirmed by the elimination of traditional cumbersome wet-sieving stage. There is no significant difference between the traditionally produced ogi and all other prepared samples considering the appearance, aroma, taste and sourness (table 6).

Table 2: Technical profiles of the two selected starter culture microorganisms for ogi production.

Table icon

LYS, Lysine overproduction; METH, Methionine overproduction; +, Positive; -, Negative; NA, Not Available

Table 3: Changes in pH and percentage total titratable acidity (%TTA) of 3-day fermented ogi gruel*

Substrate used

Fermentation Type


Percentage total titratable acidity (%TTA)

Whole maize grains


# 6.40e

# 0




(traditional method)


Dehulled maize grains alone


# 6.40e

# 0




starter cultures



Dehulled maize grains and glucose (2%w/w)




starter cultures



Dehulled maize grains, glucose (2%w/w) and soybean flour (1%w/w)




starter cultures



a-d Values in the same column with different superscripts differ significantly (p<0.05). Stated values are means of two trials.

# Results for unprocessed raw material samples. SCS, starter cultures

DMG, Dehulled maize grains

Table 4: Lysine and methionine contents of pilot-plant produced ogi sample

Samples used

Fermentation type

Lysine (mg/g)

Methionine  (mg/g)

   Oven dried     

Freeze dried

Oven dried

Freeze dried

Whole maize grains (WMG)






Dehulled maize grains (DMG)






Traditionally produced ogi from WMG






ogi from DMG alone






Starter cultures





Ogi from DMG and glucose (2 % w/w)






Starter cultures





Ogi from DMG, glucose (2% w/w) and soybean (1% w/w)






Starter cultures





a-d Values in the same column with different superscripts differ significantly (p<0.05). Stated values are means of two trials.

# Results for unprocessed raw material samples, nd, not determined

Table 5: Total amino acids, soluble protein and niacin contents of pilot-plant produced ogi samples

Samples Used

Fermentation type

Total amino acids content (mg/g)

Soluble protein content (mg/g)*

Niacin content (mg/g)*

Oven dried ogi

Freeze dried ogi

Oven dried ogi

Freeze dried ogi

Oven dried ogi

Freeze dried ogi

Whole maize grains (WMG)








Dehulled maize grains (DMG)








Traditionally produced ogi from WMG








Ogi from DMG alone








Starter cultures







Ogi from DMG and glucose (2 % w/w)








Starter cultures







Ogi from DMG, glucose (2% w/w) and soybean (1%w/w)








Starter cultures







a-d Values in the same column with different superscripts differ significantly (p<0.05). Stated values are means of two trials,

# Results for unprocessed raw material samples, nd, not determined.

Table 6: Organoleptic (sensory) assessment of ready to eat pap from pilot-plant produced ogi flour samplesa

Table icon

a Values are  means of the seven-man taste panel ± S.D.

*Values are significantly different (P>0.01) from the traditionally fermented sample from whole maize grains (control).


The selection of lysine-producing and methionine-producing SCS as reported is a cheap and safe way of improving ogi value without changing the sensory features and product acceptability [18,55]. Other features such as phytase production, reduction of pH below 4.0, degradation of oligosaccharides, no biogenic amine production are meant to further enhance the product nutritional qualities and the safety [40,56]. Isolates screened may not contain any biogenic amine producers because the environment from where they are isolated naturally contains very low protein levels hence there will be poor levels of precursors for producing biogenic amines [39]. Bacteriocinogenic isolates have been linked with ogi products safety [16,57]. The isolation of three Lactococcus strains producing bacteriocin in table 1 as in other studies, showed that future beneficial products may be generated to secure product safety and probable treat infectious pathogen if bacteriocin producers are included in the SCS composition [17,58]. SCS application in this study, has also demonstrated a unique ability to stabilize fermentation by bringing about homogeneity within fermented batches. A stable pH 3.35 was regular in three SCS fermented substrates, even with varying composition, when compared with varying pH in spontaneous fermentation. The varying pH levels observed in the spontaneously fermented controls may be attributed to the different modifications in the substrate compositions and the various types of the microorganisms that are active in spontaneous fermentations [59]. Dominant L. brevis activity in the fermenting mash enhanced by the presence of S. cerevisiae when they were both used as SCS for ogi may be responsible for the stable final pH and high acid production during SCS fermentation (Table 2) [36]. This indicate a better product shelf life since organic acids produced by lactic acid bacteria has inhibitory effect against many spoilage and pathogenic organisms [35].

Lysine and methionine producing capabilities of the starter cultures used conform to the results of Teniola & Odunfa [60] as well as Okoroafor et al. [18] on the possibility of improving food nutrients by microbial fermentation with nutrient hyper-producing microorganisms. The result confirm the presence of lysine and methionine producing Lactobacillus and yeast as well as their potential for ogi nutritional improvement [38]. Chung and Fields [61] reported a decrease in the available lysine level of cornmeal fermented with Bacillus megaterium ATCC 13639 and Enterobacter aerogenes, although a significant increase in the available methionine and tryptophan were observed. The fermentation liquor removal prior to drying and the heat applied during oven drying are major factor responsible for nutritional losses during ogi processing. Although low, the various quantities of the nutrients observed in the discarded fermentation liquor gives credence to this view (data not shown) as well as the differences observed between the nutritional status of oven- and freeze- dried samples (tables 4 and 5).

Different after taste observed in the two spontaneously fermented samples from DM alone and that from substrate fortification with glucose and soybean may indicate that more strange metabolites is been produced by other microorganisms in the spontaneous fermentation that are different from that from ogi SCS. Bacteria such as Bacillus subtilis, B. licheniformis and Staphylococcus spp. with unknown contributions during ogi fermentation have been largely isolated in various soybean-related products [62]. The lower acceptability of ogi produced from soybean-fortified raw materials agreed with past reports [63]. Better improvement in the product quality as reflected by the overall acceptability when ogi is fermented with selected microorganisms confirmed the ability to impact good features on the final products by the SCS selected (table 5).


The present result shows that the current pilot plant process can be improved nutritionally and the final product pH stabilized with higher acidity and fermentation rate by the use of well-selected cultures. The modification of the traditional fermentation substrate, WMG into dehulled maize, effectively remove the wet-sieving stage of ogi traditional production and its associated challenges. It also allows substantial reduction or control of water usage during production, which reduces nutritional losses from prolong period of final product recovery by the discarding of the excess fermentation liquor and or heat drying to obtain ogi flour. Solid-state fermentation use during ogi production will help to reduce the cost of space and water as observed in Kenkey, a related Ghanaian fermented product from maize [8,20,64]. Although, grain dehulling reduces the substrate nutrient (table 3 and 4), the use of well-selected SCS with valuable nutrient-yielding capability will remove the disadvantage during fermentation. The use of SCS for the pilot-plant production of ogi and product nutritional enhancement is a good foundation for future ogi product improvement by modern microbial biotechnological techniques. The removed hull and germs from the WMG will find good value in the livestock industry as feed and feed supplements.

Declaration of competing interest

The authors declare no conflict of interest.


The authors thankfully acknowledge US Aid Grant No. DAN-5053-G-00-1062-00 and DAAD, Germany for their support to carry out different parts of this work. The work does not necessarily reflects the sponsors’ views and in no way anticipates the organization’s future policy in the subject area. The manuscript submitted is an original research work carried out mainly at the Biotechnology Department, Federal Institute of Industrial Research, Oshodi, PMB 21023 Ikeja, Lagos, Nigeria. Part of the work was also carried out at Institut fur Hygiene und Toxikologie, Bundesforschungsanstalt fur Ernahrung, Karlsruhe DE, Germany. The authors appreciate the managements and staff of these Research Institutions for their wonderful support and contributions.


  1. Adisa A, Enujiagha VN. Microbiology and safety of ogi fermentation: A Review. European Journal of Nutrition & Food safety 12 (2020): 90-100.
  2. Soro-Yao AA, Kouakou BGA, Thonart P, et al. The use of lactic acid bacteria starter cultures during the processing of fermented cereal-based foods in West Africa: a review. Tropical life sciences research25 (2014): 81.
  3. Bolaji OT, Adepoju PA, Olalusi AP. Economic implication of industrialization of a popular weaning food ogi production in Nigeria: A review. African Journal of Food Science9 (2015): 495-503.
  4. Abioye VF, Aka MO. Proximate composition and sensory properties of moringa fortified maize-ogi. Journal of Nutrition and Food Sci12 (2015): 1-4.
  5. Makanjuola OM. Amino Acids Profile of Powdered Fermented Maize Meal (Ogi) Fortified with Powdered Unfermented Locust Bean Seeds (Parkia biglobosa). IOSR Journal of Environmental Science, Toxicology and Food Technology 11 (2017): 28-32.
  6. Okafor UI, Omemu AM, Obadina AO, et al. (2018). Nutritional composition and antinutritional properties of maize ogi co-fermented with pigeon pea. Food science & nutrition6 (2018): 424-439.
  7. Ahaotu I, Ichendu MO, Maduka N. Microbiological, nutritional and sensory evaluation of snack bars developed using Bambara groundnut (Vigna subterranean L.) and maize (Zea mays). African Journal of Microbiology Research 16 (2022): 8-23.
  8. Kpodo K, Sorensen AK, Jakobsen M. The occurrence of mycotoxins in fermented maize products. Food Chem 56 (1996): 147-153.
  9. Okeke CA, Ezekiel CN, Nwangburuka CC, et al. Bacterial diversity and mycotoxin reduction during maize fermentation (steeping) for ogi production. Frontiers in Microbiology6 (2015): 1402.
  10. Okeke CA, Ezekiel CN, Sulyok M, et al. Traditional processing impacts mycotoxin levels and nutritional value of ogi–a maize-based complementary food. Food Control86 (2018): 224-233.
  11. Onwuakor CE, Nwaugo VO, Nnadi CJ, et al. Effect of varied culture conditions on crude supernatant (bacteriocin) production from four Lactobacillus species isolated from locally fermented maize (ogi). American Journal of Microbiological Research2 (2014): 125-130.
  12. Adegbehingbe KT. Fermented sprouted and unsprouted maize for ogiInternational Journal of advanced research 1 (2013): 428-434.
  13. Akinleye OM, Fajolu IO, Fasure AK, et al. Evaluation of microorganisms at different stages of production of Ogi in Alimosho Community, Area Southwest, Lagos, Nigeria. American Journal of Research Communication2 (2014): 215-230.
  14. Ashiru AW, Teniola OD, Dibiana NN, et al. Isolation of starch degrading spoilage bacteria from ogi (fermenting maize starch). Pakistan Journal of Nutrition11 (2012): 243.
  15. Adebukunola M. Omemu A. M., Mobolaji O. Bankole Consumer’s Knowledge, Attitude, Usage and Storage Pattern of Ogi- A Fermented Cereal Gruel in South West, Nigeria. Food and Public Health 5 (1995): 77-83.
  16. Olasupo NA, Olukoya DK, Odunfa SA. Assessment of a bacteriocin-producing Lactobacillus strain in the control of spoilage of a cereal-based African fermented food. Folia Microbiologica 42 (1997): 31-34.
  17. Olukoya DK, Ebigwei SI, Olasupo NA, et al. Production of `DogiK´: an improvedogi (Nigeria fermented weaning food) with potential for use in diarrhoea control. Trop. Pediatrics 40 (1994): 108-13.
  18. Okoroafor I, Banwo K, Olanbiwoninu AA, et al. Folate enrichment of Ogi (a fermented cereal gruel) using folate producing starter cultures. Advances in Microbiology9 (2019): 177.
  19. Teniola OD. Invisible soldiers and fermentation: Impact on food security and industrialization. Olusegun Agagu University of Science and Technology (OAUSTECH), Okitipupa, Nigeria. Inaugural Lecture Series 1 (2021): 107
  20. Jespersen L, Halm M, Kpodo K, et al. Significance of yeasts and moulds occurring in maize dough fermentation for KenkeyInternational Journal of Food Microbiology 24 (1994): 239-248.
  21. Omemu AM. Fermentation dynamics during production of ogi, a Nigerian fermented cereal porridge. Report and Opinion3 (2011): 8-17.  
  22. Subuola F, Widodo Y, Kehinde T. Processing and utilization of legumes in the tropics. Trends in vital food and control engineering 12 (2012): 71-84.
  23. Olunike AA. Utilization of legumes in the Tropics.  Biol. Agric. Healthcare4 (2014): 77-84.
  24. Omemu AM, Okafor UI, Obadina AO, et al. Microbiological assessment of maize ogi cofermented with pigeon pea. Food Science & Nutrition6 (2018): 1238-1253.
  25. Abu-Ghannam N, Gowen A. Pulse-based food products. In Pulse FoodsAcademic Press). Assessment of chemical, rheological and sensory properties of fermented maize-cardaba banana complementary food (2021): 369-391.
  26. Ayo-Omogie HN, Ogunsakin R. Assessment of Chemical, Rheological and Sensory properties of fermented maize-cardaba banana complementary food. Food and Nutrition Sciences 4 (2013): 844-850.
  27. Wang X, Zhang J, Dong E, et al. Identification of QTLs for niacin concentration in maize kernels. Plant Breeding 138 (2019): 5: 534-545.
  28. Müntz K, Christov V, Saalbach G, et al. Genetic engineering for high methionine grain legumes. Nahrung 42 (1998): 125-127.
  29. Kohlmeier Methionine: Food Metabolism. Food Science and Technology, Academic Press (2003): 338-348.
  30. Galili, G. and Amir, R. Fortifying plants with the essential amino acids lysine and methionine to improve nutritional quality. Plant Biotechnol. J 11 (2013): 211-222.
  31. Sangwan S, Kumar S, Goyal S. Maize utilisation in food bioprocessing: An overview. Maize: nutrition dynamics and novel uses 4 (2014): 119-134.
  32. Achi OK, Ukwuru M. Cereal-based fermented foods of Africa as functional foods. International Journal of Microbiology and Application2 (2015): 71-83.
  33. Saranraj P, Naidu MA, Sivasakthivelan P. Lactic acid bacteria and its antimicrobial properties: a review. Int J Pharm Biol Arch4 (2013): 1124-1133.
  34. Mokoena MP, Mutanda T, Olaniran AO. Perspectives on the probiotic potential of lactic acid bacteria from African traditional fermented foods and beverages. Food & Nutrition Research60 (2016): 29630.
  35. Agriopoulou S, Stamatelopoulou E, Sachadyn-Król M, et al. Lactic acid bacteria as antibacterial agents to extend the shelf life of fresh and minimally processed fruits and vegetables: Quality and safety aspects. Microorganisms8 (2020): 952.
  36. Egwim EAM, Abubakar Y, Mainuna B. Nigerian indigenous fermented foods: processes and prospects. Mycotoxin and food safety in developing countries153 (2013).
  37. Tsafrakidou P, Michaelidou AM, Biliaderis G, et al. Fermented cereal-based products: Nutritional aspects, possible impact on gut microbiota and health implications. Foods 9 (2020):
  38. Odunfa SA, Adeniran SA, Teniola OD, et al. Evaluation of lysine and methionine production in some lactobacilli and yeasts from ogi. International Journal of Food Microbiology 63 (2001): 159-163.
  39. Barbieri F, Montanari C, Gardini F, et al. Biogenic Amine Production by Lactic Acid Bacteria: A Review. Foods 8 (2019): 17. 
  40. Adesulu DAT, Jeyaram K, Sanni AI. Probiotic and technological properties of exopolysaccharide producing lactic acid bacteria isolated from cereal-based Nigerian fermented food products. Food Control92 (2018): 225-231.
  41. Olatunde OO, Obadina AO, Omemu AM, et al. Screening and molecular identification of potential probiotic lactic acid bacteria in effluents generated during ogiAnnals of Microbiology 68 (2018): 433-443.
  42. Ajayeoba TA, Dula S, Ijabadeniyi OA. Properties of poly-γ-glutamic acid producing-Bacillus species isolated from ogi liquor and lemon-ogi liquor. Frontiers in Microbiology 10 (2019):
  43. Onwuakor CE, Nwaugo VO, Nnadi CJ, et al. Effect of varied culture conditions on crude supernatant (bacteriocin) production from four Lactobacillus species isolated from locally fermented maize (ogi). American Journal of Microbiological Research2 (2014): 125-130.
  44. Ohenhen RE, Isibor JO, Emonfonmwan G, et al. Effects of pH and storage temperatures on antibacterial activity of bacteriocin produced by lactic acid bacteria isolated from ogi. Br Microbiol Res J9 (2015): 1-9.
  45. Onipede G, Aremu B, Sanni A, et al. Molecular study of the phytase gene in lactic acid bacteria isolated from Ogi and Kunun-Zaki, African fermented cereal gruel and beverage. Applied Food Biotechnology7 (2020): 49-60.
  46. Urs VSR., Ramlal S, Batra HV, et al. An In-vitro screening for biogenic amines producing microorganisms from fermented foods and its degradation by bacteria from canine saliva. Pure Appl Microbiol 13 (2019): 271-280.
  47. Ukwuru MU, Ibeneme CI. Biotechnological Properties of Microorganisms Isolated from Traditional Fermented Foods. Focusing on Modern Food Industry3 (2014):
  48. Moreno-Arribas MV, Polo MC, Jorganes F, et al. Screening ofbiogenic amine production by lactic acid bacteria isolated from grape must and wine.International Journal of Food Microbiology 84 (2003): 117-123.
  49. Methods of Analysis 20th Edition Association of Official Analytical Chemists. Washington, DC (2016).
  50. Jakšic S, Jajic I, Krstovic S, et al. L-lysine determination in animal feed using microbiological microtiter plate assay. Journal of the Hellenic Veterinary Medical Society 69 (2018): 1094-1100.
  51. Rosen HA. A modified ninhydrin colourimetric analysis of amino acids. Arch Biochem Biophy 67 (1957): 10-15.
  52. Waterborg JH, Matthew HR. The protein protocols handbook.  Springer Protocols Handbooks(SPH), Walker J.M. (Ed.), (2009), pp: 7-10. 
  53. Wright A, Orman B. Rapid screening procedure for methionine levels in maize and soybean. Crop science35 (1995): 584-586.
  54. Cass T. Statistical methods in management. Casel Ltd., 35 Red Lion square, London WCIR, 2 (1980): 1-255
  55. Oyewole OB. Optimization of cassava fermentation for fufu production: effects of single starter cultures. Journal of Applied Bacteriology68 (1990): 49-54.
  56. Adesulu-Dahunsi AT, Sanni AI, Jeyaram K. Diversity and technological characterization of Pediococcus pentosaceus strains isolated from Nigerian traditional fermented foods. LWT140 (2021):
  57. Omemu AM, Faniran OW. Assessment of the antimicrobial activity of lactic acid bacteria isolated from two fermented maize products-ogi and kunnu-zaki. Malaysian Journal of Microbiology 7 (2011): 124-128.
  58. Teniola OD, Holzapfel WH, Odunfa SA. Comparative assessment of fermentation techniques useful in the processing of ogi. World Journal of Microbiology and Biotechnology21 (2005): 39-43.
  59. Adebo OA, Njobeh PB, Kayitesi E. Fermentation by Lactobacillus fermentum strains (singly and in combination) enhances the properties of ting from two whole grain sorghum types. Journal of cereal science82 (2018): 49-56.
  60. Teniola OD, Odunfa SA. The effects of processing methods on the levels of lysine, methionine and the general acceptability of ogi processed using starter cultures. International Journal of Food Microbiology63 (2001): 1-9.
  61. Chung HJ, Fields ML. Production of riboflavin and vitamin B12 by Bacillus megaterium ATCC 13639 and Enterobacter aerogenes in corn meal. J Food Sci 51 (1986): 1514-1517.
  62. Ugwuanyi JO, Okpara AN. Current Status of Alkaline Fermented Foods and Seasoning Agents of Africa. In New Advances on Fermentation Processes. London, UK: IntechOpen (2019).
  63. Onoja US, Akubor PI, Gernar DI, et al. Evaluation of complementary food formulated from local staples and fortified with calcium, iron and zinc. Journal of Nutrition and Food Sciences4 (2014): 1-6.
  64. Halm M, Lillie A, Sorensen AK, Jakobsen M. Microbiological and aromatic characteristics of fermented maize doughs for kenkey production in Ghana. Intern J Food Microbiol 19 (1993): 135-143.

© 2016-2024, Copyrights Fortune Journals. All Rights Reserved